Triple-effect falling film evaporator/ vacuum concentrator for juice / milk / whey
Energy save, high evaporation speed, can be PLC control
Application:
The Falling film evaporator is applicable for dairy products, pharmacy, glucose, starch, chemical industry, xylose, citric acid, ammonium sulfate, biological engineering, environment engineering and waste liquid recovery and treatment etc.
Composition:
It contains of 1st-effect, 2n-effect and 3rd-effect evaporators, 1st-effect, 2n-effect and 3rd-effect separators, pre-heater, condenser and hot pressure pump.
Equipment characteristics:
(1) Low evaporation consumption, 1Kg steam can evaporate 3.5Kg water.
(2) Low evaporation temperature. Part of twice steam can be inhaled into single-effect heater through spray type hot pressure pump. The high quality evaporation can be fully used and the evaporation temperature is low.
(3) Large concentration ratio with downward film type evaporation, which can make material liquid with viscosity be so easy to flow and evaporate, Hard to agglomerate with
short concentration time. The concentration ratio can reach 1:5.
(4) The equipment can realize automatic production, intellectual system, which is conformity with GMP standard.
Technical parameters:
Model | FFE-500 | FFE-1000 | FFE-1500 | |
Evaporated capacity(kg/h) | 500 | 1000 | 1500 | |
Steam pressure(Mpa) | Single effect | 80-90 | 85-95 | 85-95 |
Double effect | 65-75 | 65-75 | 65-75 | |
Three effect | 55-60 | 55-60 | 55-60 | |
Vacuum degree(Mpa) | Single effect | 0.04 | 0.04 | 0.04 |
Double effect | 0.06 | 0.06 | 0.06 | |
Three effect | 0.08 | 0.08 | 0.08 | |
Concentrated rate | 1.35 | 1.35 | 1.35 | |
Steam consumption(kg/h) | 230 | 350 | 600 | |
Recycle water(T) | 5 | 8 | 15 | |
Steam inlet(Φ) | 32 | 43 | 57 | |
Vacuum tube(Φ) | 80 | 109 | 159 | |
Dimension(L*W*H)mm | 5400*1000*2800 | 7000*1500*3400 | 8250*1600*3600 |
Packing:
Strong seaworthy wooden case/wooden support/Iron support.
(1) LCL (Less container load) Pack by waterproof plastic film first,then pack by plywood.
(2) FCL(Full container load) Fixed on wooden support by steel wire.
(3) If large tank, pack by waterproof plastic film first, then fixed on wooden support by steel wire.